________________________________________________________________________________________
Honda GX340 Troubleshooting
| Engine Model: Honda GX340 |
| Engine Type: 4-cycle overhead valve 1-cylinder air-cooled gasoline engine |
| Total Displacement: 20.6 cu.in (337 cc) |
| Rated Engine Power: 11 Hp (8.2 kW) at 3600 rpm |
| Fuel System: Horizontal carburetor with butterfly valve |
| Engine doesn't start or starts hard |
Gas tank is empty - Fill fuel up.
Incorrect fuel grade - Use quality gasoline.
Dirty fuel system - Check and clean.
Defective spark plug wire connection - Check the spark plug wire connection, repair or replace.
Spark plug is damaged - Spark plug need to be replaced.
Clogged fuel filter - Fuel filter needs to be replaced.
Brake pedal not pushed down - Push the brake pedal down.
Carburetor is not adjusted - Check carburetor float adjustment.
Poor engine compression - Check cylinder block and replace damaged components.
Damaged or not adjusted choke cable - Adjust correctly or replace the cable.
| Engine runs intermittently |
Plugged cooling fins - Clean and wash as required.
Ignition system is defective - Inspect ignition system and change failed components.
Throttle cable is stuck or defective - Service or change the cable.
Air filter is blocked - Clean or replace air filter.
Fuel pump is defective or dirty - Clean or change fuel pump.
| Engine starts and stops suddenly |
Damaged spark plug - Replace spark plug.
Carburetor is clogged or defective - Replace or service carburetor.
Defective ignition coil - Ignition coil must be replaced.
Broken or loose valve springs - New valve springs need to be installed.
Stuck valves - Service the valves.
Lack of engine oil - Checking oil level and add if necessary.
Engine overloaded - Load reducing is recommended.
Air intake screen is plugged - Clean and wash as required.
Too lean fuel mixture in carburetor - Use proper settings.
Bad ignition timing - Adjust ignition timing correctly.
Wrong valve setting - Adjust valves correctly.
| Abnormal engine knocking or noise |
Stale fuel - Change gasoline.
Engine is overloaded - Load reducing is recommended.
Not enough engine oil - Checking oil level and add if necessary.
Low idle speed setting is incorrect - Adjust the low idle speed.
Fuel pump is defective or dirty - Service or change fuel pump.
Crankshaft or main bearings failure - Have bearings or crankshaft replaced.
Excessive valve clearance - Check and adjust.
Cylinder bore or piston rings are damaged - Change defective components.
Carburetor is clogged or improperly adjusted - Clean or properly adjust carburetor.
Air filter is blocked - Clean or replace air filter.
Clogged or defective fuel pump - Inspect fuel pump and change as required.
Ignition system problems - Inspect ignition system and change faulty parts.
Defective cylinder head gasket - Change cylinder head gasket.
Valves are stuck or burned - Clean or change valves.
Worn or defective push rod - Push rod needs to be changed.
Worn cylinder block components - Change defective components.
Oil filter element is plugged (if equipped) - Service or change oil filter.
| Engine uses too much fuel |
Choke is not fully open - Check choke cable and adjust it.
Incorrect adjustment of carburetor main jet - Adjust the carburetor main jet properly.
Spark plug is defective or loose - Tighten or replace spark plug.
Valves are stuck, burned, or worn - Service or change valves.
Sleeve, piston, or rings are damaged - Replace faulty parts.
Valve clearance is not correct - Check and adjust.
| Engine consuming too much oil |
Gaskets or seals are excessively worn - Replace defective parts.
Worn valve stems and valve guides - Valves need to be changed.
Piston rings are stuck or worn - Have piston rings replaced.
Scuffed piston or cylinder liner - Inspect liner and piston, change as necessary.
Plugged breather hose or pipe - Clean or replace.
________________________________________________________________________________________
________________________________________________________________________________________
| Engines Technical Specifications |
| Lawn and Garden Tractors Technical Specs |
| Farm Tractors Technical Specifications |
